Leisure vehicles

1. Engine

block and all internal lubricated parts including the cylinder head, crankshaft, crankshaft bearings, camshaft, camshaft bearings, oil pump, cam followers, flywheel (modified excluded), timing chain – guides, tensioners and covers, sprockets, pistons, piston rings, connecting rods, pushrods, connecting rod bushings, rocker arms, rocker arm bushings, valve guides, valve lifters, valve springs, valve retainers, valve seats, valve covers and gaskets, intake manifold, exhaust manifold, diaphragms, oil pan, engine mounts. All related seals and gaskets included for any major repair mentioned above. (minor leaks not considered as major repairs and are not included in the program).
Turbocompresseur : (if applies, factory installed only) : turbo case (if the inside is damaged) and all internal lubricated parts including the turbine(s), compressor shaft, bypass valves / waste gate, bushings.

Turbocompressor

turbo case (if the inside is damaged) and all internal lubricated parts including the turbine(s), compressor shaft, bypass valves / waste gate, bushings.

2. Drive system

• Transmission : case and all internal lubricated parts including the gears, bearings, flywheel, oil pan, mounts. All related seals and gaskets included for any major repair mentioned above. (minor leaks not considered as major repairs and are not included in the program).

• Primary Drive System : housing and all internal lubricated parts including the sheaves, gears, drive chain and chain adjuster mechanism, bearings, bushings, flywheels, sprockets. All related seals and gaskets included for any major repair mentioned above. (minor leaks not considered as major repairs and are not included in the program).

• Differential : Trans-axle final drive housing and all internal lubricated parts including differential covers, axle shafts, drive shafts, hub bearings and rings, forks, universal joint, constant velocity joints, CV boots, mounts. All related seals and gaskets included for any major repair mentioned above. (minor leaks not considered as major repairs and are not included in the program).

• Transfer case : Housing and all internal lubricated parts, also including the four-wheel drive control system, actuators, encoder motor. All related seals and gaskets included for any major repair mentioned above. (minor leaks not considered as major repairs and are not included in the program).

• Secondary Drive System : cam assembly, sheaves – fixed and moveable, secondary shaft and bearings, bushings. All related seals and gaskets included for any major repair mentioned above. (minor leaks not considered as major repairs and are not included in the program).

3. Direction

Axle, steering stem shaft, steering shaft rings and bearings, bushings and nuts, steering tie-rod ends, steering links, steering link ends, spindle bushings, idler arm, pitman arm, rack and pinion assembly, handle bar.

4. Front and rear suspension

Swing arm and frame, swing arm shaft, swing arm shaft bushings and bearings, upper and lower control arms, wheel arms, spindles, knuckles and bearings, ball joints, all internally lubricated parts in the front fork tubes and front hubs.

5. Brakes

Master cylinder, calipers, brake hubs, drum brake actuating cam / modulator, ABS command unit, speed sensor, hydraulic brake lines and fittings.

6. Fuel system

Fuel pump, injection pump, injectors, fuel tank, fuel tank sending unit, fuel pressure regulator, fuel flow valve (Petcock), metallic lines and fittings.

• Oil Injection System (if applies): oil pump, oil injection drive gear, oil injection regulator, oil tank, oil level sensor, metallic lines and fittings.

7. Cooling system

Cooling fan motor and shafts, cooling fan sensor, water pump, radiator / heat exchanger, thermostat, temperature gauge.

8. Electrical system

Alternator, magneto, rotor, stators, rectifier, voltage regulator, starter, starter solenoid, distributor, ignition coils (electric), wiring harness, electronic control module (ECM), electronic ignition module (CDI), ignition switch and lock cylinder, brake light switch, headlight switch, turn signal switches.

9. Road side service

A reimbursement up to fifty dollars (50$ CAD) will be authorised for any road side service used within Canada and/or the United States per year during the term indicated for this present leisure vehicle warranty. The owner of the vehicle is responsible to provide any proof of invoicing required by Produits Avantage Plus.

10. Rental vehicle

A reimbursement up to fifty dollars (50$ CAD) per day will be authorised, for a maximum of four (4) days total during the term indicated for this present leisure vehicle warranty if the repair is covered by the conditions indicated in the program and approved by Produits Avantage Plus. The owner of the vehicle is responsible to provide any proof of invoicing required by Produits Avantage Plus.

11. Lodging

A reimbursement up to seventy-five dollars (75 $ CAD) will be authorised, for a total of four (4) days maximum during the term indicated for this present leisure vehicle warranty if the repair is covered by the conditions indicated in the program and approved by Produits Avantage Plus. The vehicle must be immobilized more than three hundred (300 km) from the address indicated of the vehicle owner for this reimbursement to apply. The owner of the vehicle is responsible to provide any proof of invoicing required by Produits Avantage Plus.